Analysis of the peak particle velocity and the bonding state of shotcrete induced by the tunnel blasting

Eui-Joon* Hong; Seok-Bue Chang; Ki-il Song; Gye-Chun Cho

doi:None

All Issue

2010 Vol.12, Issue 3 Preview Page Next Page

Analysis of the peak particle velocity and the bonding state of shotcrete induced by the tunnel blasting 발파시 터널 숏크리트의 최대입자속도와 부착상태평가 분석

31 May 2010. pp. 247-255

PDF XML

Abstract

Bonding strength of shotcrete is a significant influential factor which plays the role of collapse prevention of tunnel crown and of debonding prevention of shotcrete induced by the blasting vibration. Thus, the evaluation of the shotcrete bonding state is one of the core components for shotcrete quality control. In this study, the peak particle velocities induced by blasting were measured on the shotcrete in a tunnel construction site and its effect on the bonding state of shotcrete is investigated. Drilling and blasting technique was used for the excavation of intersection tunnel connecting the main tunnel with the service tunnel. Blast-induced vibrations were monitored at some points of the main tunnel and the service tunnel. The shotcrete bonding state was evaluated by using impact-echo test coupled with the time-frequency domain analysis which is called short-time Fourier transformation. Analysis results of blast-induced vibrations and the time-frequency domain impact-echo signals showed that the blasting condition applied to the excavation of intersection tunnel hardly affects on the tunnel shotcrete bonding state. The general blasting practice in Korea was evaluated to have a minor negative impact on shotcrete quality.

Keywords

Blast-induced vibration

bonding state

shotcrete

time-frequency domain analysis

impact-echo test

숏크리트의 부착강도는 천정부의 낙반방지와 발파진동에 의한 숏크리트 탈락방지에 중요한 역할을 하는 요소이다. 따라서, 숏크리트의 부착상태평가는 품질관리의 주요 요소가 될 수 있다. 본 연구는 터널 내 발파에 의하여 숏크리트에 미치는 최대 입자속도를 예측하고, 발파 진동에 의한 숏크리트의 부착상태를 평가하기 위하여 수행되었다. 이를 위하여 현재 시공중인 터널현장에서 피난연락갱의 발파시 본선부 및 서비스 터널의 발파진동을 측정하였으며 충격반향시험을 수행하여 숏크리트-암반의 부착상태를 평가하였다. 충격반향시험 신호분석을 위하여 시간-주파수 영역 해석 기법을 도입하였으며 평가결과, 국내에서 일반적으로 시행되는 발파조건에서는 숏크리트와 암반의 부착력 손실(들뜸 현상)은 거의 발견되지 않았으며, 숏크리트 부착력 손상 가능성은 낮은 것으로 판단되었다.

키워드

발파진동

부착상태

숏크리트

시간-주파수 영역 해석

충격반향시험

References

1.문상조, 장석부, 정준화 (1999), “지하철 대단면 터널의 설계와 시공관리 사례”, 한국지반공학회 1999년 봄학술 발표회 논문집, pp. 265-292.

2.송기일, 조계춘, 장석부 (2008), “충격 반향 기법을 이용한 숏크리트 배면 접착 상태 평가에 관한 수치해석적 연구”, 한국터널공학회논문집 터널기술, 제9권, 제2호, pp. 109-120.

3.송기일, 조계춘, 장석부, 홍은수 (2009), “비파괴 시험 기법을 이용한 숏크리트 배면 접착상태 평가에 관한 실험적 연구”, 한국터널공학회논문집 터널기술, 제11권, 제1호, pp. 71-83.

4.안경철, 신재근, 김재동, 원광연, 김택곤 (2004), “숏크리트의 부착강도 측정을 통한 지보설계”, 한국암반공학회춘계학술발표회, pp. 31-45.

5.장석부, 홍의준, 문상조 (2005), “대단면 암반터널의 안정성에 미치는 숏크리트 부착강도의 영향에 관한 연구”, 한국터널공학회논문집 터널기술, 제7권, 제4호, pp. 305-312.

6.Ansell, A. (2002) “A literature review on the vibration resistance of young and early age concrete”, Structural Engineering Royal Institute of Technology (KTH).

7.Ansell, A. (2004) “In situ testing of young shotcrete subjected to vibration from blasting”, Tunnelling and Underground Space Technology Vol. 19, pp. 587-596.

8.Carino, NJ. and Sansalone M. (1992), “Detection of voids in grouted ducts using the impact-echo method”, ACI Mater J, Vol. 89, No. 3, pp. 296-303.

9.Cartwright, P., Clifford, B., Armanen, E. and Vuori, A. (2001), “Application of the acoustic energy meter for assessment of tunnel lining condition”, Proceeding of the ISRM regional symposium EUROCK, Espoo, Finland, pp. 333-338.

10.Davis, AG., Malcolm, KL. and Petersen, CG. (2005), “Rapid and economical evaluation of concrete tunnel linings with impulse response and impulse radar non-destructive methods”, NDT & E International, Vol. 38, pp. 181-186.

11.Gibson, A. and Popovics, JS. (2005), “Lamb Wave Basis for Impact-Echo Method Analysis”, J Eng Mech., Vol. 131, No. 4, pp. 438-443.

12.Kendorski, F.S., Jude, C.V. and Duncan, W.M. (1973), “Effect of blasting on shotcrete drift linings”, Min. Eng., Vol. 25, pp. 38-41.

13.McCreath, D.R., Tannant, D.D. and Langille, C.C. (1994), “Survivability of shotcrete near blasts”, Nelson, Laubach, (Eds.), Rock Mechanics, Balkema, Rotterdam, pp. 277-284.

14.Melbye, T. (2001),“Sprayed concrete for rock support”, MBT International, pp.154-155

15.Nakano, K., Okada, S., Furukawa, K. and Nakagawa, K. (1993), “Vibration and cracking of tunnel lining due to adjacent blasting”, Doboku Gakkai Rombun-Hokokushu, Proceedings of the Japan Society of Civil Engineers, Vol. 462, pp. 53-62. (in Japanese, Abstract in English).

16.Sansalone, M. and Streett, WB. (1997), Impact-Echo: Nondestructive Evaluation of Concrete and Masonry. New York, Bullbrier Press, pp. 338.

17.Song, K.I. and Cho, G.C. (2009), “Bonding state evaluation of tunnel shotcrete applied onto hard rocks using the impact-echo method”, NDT & E International, Vol. 42, pp. 487-500.

18.Tannant, D.D. and McDowell, G.M. (1993), “Dynamic testing of shotcreted drifts”, GRC Internal Report 93-12-IR, GRC, Laurentian University, Sudbury, pp. 20.

19.Wood, D.F. and Tannant, D.D. (1994), “Blast damage to steel fibrereinforced shotcrete”, Fiber Reinforced Concrete-Modern Developments, UBC Press. pp. 241-250.

20.Xie, X., Liu, Y., Huang, H., Du, J., Zhang, F. and Liu, L. (2007), “Evaluation of grout behind the lining of shield tunnels using ground-penetrating radar in the Shanghai Metro Line, China”, J. Geophys. Eng., Vol. 4, pp. 253-261.

https://cdn.apub.kr/journalsite/sites/kta/2010-012-03/N0550120305/images/PIC6543.gif

Information

Publisher :Korean Tunneling and Underground Space Association
Publisher(Ko) :한국터널지하공간학회
Journal Title :Journal of Korean Tunnelling and Underground Space Association
Journal Title(Ko) :한국터널지하공간학회 논문집
Volume : 12
No :3
Pages :247-255
Received Date : 2010-03-31
Revised Date : 2010-05-06
Accepted Date : 2010-05-26

Journal of Korean Tunnelling and Underground Space Association ISSN:2233-8292(Print) 2287-4747(Online) 한국터널지하공간학회 논문집

All Issue