Flexural performance evaluation of fiber reinforced segments with GFRP plate

Ri-On Oh; Sung-Ki Park; Sang-Kyung Sung; Jae-Young Lee; Hwang-Hee Kim

doi:10.9711/KTAJ.2018.20.5.839

All Issue

2018 Vol.20, Issue 5 Preview Page Next Page

Flexural performance evaluation of fiber reinforced segments with GFRP plate GFRP plate를 적용한 섬유보강세그먼트의 휨성능 평가

30 September 2018. pp. 839-854

PDF XML

Abstract

This study was performed to evaluate the performance of GFRP plate reinforced segments for TBM tunnel support. Recently, the SFRC segment has been applied to prevent local damage such as reduction of the amount of reinforcing bars of the segment, crack control and breakage. However, the steel fiber used in the SFRC segment has a problem of durability deterioration due to fiber corrosion. Compared with the RC segment, the maximum flexural load reduction of the SFRC segment hinders the broad application range of the TBM tunnel segment. Therefore, GFRP plate was considered as a stiffener for the maximum load increase of SFRC segment, and structural synthetic fiber without corrosive concern was used as a substitute for steel fiber. The flexural performance of the segment was evaluated by using the type of reinforcing fiber and GFRP plate thickness as the main parameters. As a result, the maximum load and the flexural toughness were increased by 21.78~23.03% and 0.5~7.96%, respectively, as compared with the segments reinforced with reinforcing fiber and GFRP plate of 3 mm thickness.

Keywords

TBM

Segment

Flexural performance

GFRP

Fiber reinforcement

본 연구는 GFRP plate 보강세그먼트를 TBM 터널 지보재로 적용하기 위한 성능평가를 실시하였다. 세그먼트의 철근량 감소와 균열제어 및 파손 등의 국부적인 손상 방지를 위하여 최근 SFRC세그먼트 적용되고 있다. 그러나 SFRC세그먼트에 사용되는 강섬유는 섬유 부식에 의한 내구성 저하 문제가 제기되고 있으며, RC세그먼트와 비교하여 SFRC세그먼트의 최대 휨하중 감소는 TBM 터널 세그먼트의 폭넓은 적용범위를 저해하고 있다. 따라서 SFRC세그먼트의 최대하중 증가를 위한 보강재로 GFRP plate 고려하였으며, 강섬유의 대체재로 부식 우려가 없는 구조용 합성섬유를 사용하였다. 보강섬유의 종류 및 GFRP plate 두께를 주요 변수로 하여 세그먼트의 휨 성능평가를 실시한 결과, 보강섬유와 3 mm 두께의 GFRP plate로 보강한 세그먼트는 섬유로만 보강한 세그먼트와 비교하여 섬유 종류별로 최대하중이 21.78~23.03%, 휨인성은 0.5~7.96% 증가하여 우수한 휨성능 효과를 보여주었다.

키워드

TBM

세그먼트

휨성능

유리섬유강화플라스틱

섬유보강

References

Abbas, S. (2014), “Structural and durability performance of precast segmental tunnel linings”, Electronic Thesis and Dissertation Repository, pp. 1865.

Chang, S.H., Lee, G.P., Choi, S.W., Bae, G.J. (2011), “State of the art of segment lining in shield tunnel and statistical analysis of its key design parameters”, Tunnel and Underground Space, Vol. 21, No. 6, pp. 427-438.

Kang, Y.T., Kim, G.Y., Lee, B.K., Lee, S.K., Kim, G.T, Nam, J.S. (2017), “Flexural behavior of fiber-reinforced concrete by fiber types”, Proceedings of the 2017 Fall Symposium of the Korea Institute of Building Construction, Busan, Vol. 17, No. 2, pp. 15-16.

Ku, D.O., Kim, S.D., Kim, H.S., Choi, K.K. (2014), “Flexural performance characteristics of amorphous steel fiber-reinforced concrete”, Journal of the Korea Concrete Institute, Vol. 26, No. 4, pp. 483-489.

10.4334/JKCI.2014.26.4.483

Lee, G.P., Bae, G.J., Moon, D.Y., Kang, T.S., Chang, S.H. (2013), “Evaluation of steel fiber reinforcement effect in segment lining by full scale bending test”, Journal of Korean Tunnelling and Underground Space Association, Vol. 15, No. 3, pp. 215-223.

10.9711/KTAJ.2012.14.3.21510.9711/KTAJ.2013.15.3.215

Lee, J.H., Kim, H.H., Park, S.K., Oh, R.O., Kim, H.D., Park, C.G. (2018), “Mechanical properties and durability of latex-modified fiber-reinforced concrete: a tunnel liner application”, Advances in Materials Science and Engineering, Vol. 2018, pp. 14.

10.1155/2018/2134873

Lee, J.Y., Kim, H.H., Oh, R.O., Sung, S.K., Park, S.K. (2016), “A study on TBM segments design for sharp-curved construction of small-diameter utility tunnel in urban”, Proceedings of the KSCE 2016 Convention Program, Jeju, pp. 196-197.

Moon, D.Y., Chang, S.H., Bae, G.J., Lee, G.P. (2012), “Evaluation of tensile properties of SFRC for TBM tunnel segment”, Journal of Korean Tunnelling and Underground Space Association, Vol. 14, No. 3, pp. 247-260.

10.9711/KTAJ.2012.14.3.247

Moon, D.Y., Kang, T.S., Chang, S.H., Lee, G.P., Bae, G.J. (2013), “Flexural performance evaluation of SFRC with design strength of 60 MPa”, Journal of Korean Tunnelling and Underground Space Association, Vol. 15, No. 3, pp. 175-186.

10.9711/KTAJ.2013.15.3.175

Park, Y.H., Choi, Y. (2013), “Flexural behaviors of GFRP rebars reinforced concrete beam under accelerated aging environments”, Journal of the Korea Concrete Institute, Vol. 25, No. 2, pp. 137-144.

10.4334/JKCI.2013.25.2.137

Seo, D.W., Park, K.T., You, Y.J., Park, J.S. (2016), “Study on applicability of steel-hybrid GFRP rebar to concrete structures”, Journal of the Korean Society for Advanced Composite Structures, Vol. 7, No. 4, pp. 11-17.

10.11004/kosacs.2016.7.4.011

Sim, J.S., Kwon, H.W., Lee, H.H., Kang, T.S. (2010), “An experimental study for bending characteristic of concrete beam reinforced with FRP rebar under fatigue”, Journal of Engineering and Technology, Vol. 20, No. 1, pp. 31-38.

Woo, S.J., Yoo, C.S. (2015), “A study on the member forces of segmental linings considering key segments”, Journal of Korean Tunnelling and Underground Space Association, Vol. 17, No. 3, pp. 363-382.

10.9711/KTAJ.2015.17.3.363

Yoo, C.S., Jeon, H.M. (2012), “A comparative study on methods for shield tunnel segment lining sectional forces”, Journal of Korean Tunnelling and Underground Space Association, Vol. 14, No. 3, pp. 159-181.

10.9711/KTAJ.2012.14.3.159

Yun, D.S., Kim, J.H., Choi, S.C., Lee, M.J. (2011), “A case for domestic development of shield machine and construction”, Proceedings of The 12th KTA International Symposium on Mechanized Tunnelling Technology, Seoul, pp. 169-180.

Information

Publisher :Korean Tunneling and Underground Space Association
Publisher(Ko) :한국터널지하공간학회
Journal Title :Journal of Korean Tunnelling and Underground Space Association
Journal Title(Ko) :한국터널지하공간학회 논문집
Volume : 20
No :5
Pages :839-854
Received Date : 2018-07-05
Revised Date : 2018-07-26
Accepted Date : 2018-07-31
DOI :https://doi.org/10.9711/KTAJ.2018.20.5.839

Journal of Korean Tunnelling and Underground Space Association ISSN:2233-8292(Print) 2287-4747(Online) 한국터널지하공간학회 논문집

All Issue